The typical smelting wastewater is with characteristics of high concentration of TDS, conductivity, heavy metal ions, and low concentration of COD. The ultrafiltration (UF) and reverse osmosis (RO) is an attractive technology to reclaim and reuse this kind of wastewater. In this work, Coagulation-flocculation-sedimentation (CFS) and multi-media filter (MMF) was used as the pretreatment processes. UF, RO and concentration RO (CRO) processes was applied as the advanced treatment processes to reclaim the smelting wastewater. To enlarge the recovery of RO and CRO units, the influences of increasing the feed temperature by waste heat from the smelting plant and the feed pressure by change the operating frequency of the high pressure pumps were investigated. The optimize operation parameters of RO and CRO units were obtained. To understand the operation CIP cycle time of UF, RO and CRO membrane units in a long term operation, the trans-membrane pressure (TMP) and permeate flux difference were investigate. Good system operation stability, permeate flux recovery after CIP and qualified treated water were obtained in the recommend operation parameters. The results of this work can benefit to the designing of reclaiming the smelting wastewater by UF-RO-CRO approach within the Lead and Zinc smelting industrial application.
| Published in | Journal of Energy, Environmental & Chemical Engineering (Volume 6, Issue 4) |
| DOI | 10.11648/j.jeece.20210604.11 |
| Page(s) | 94-105 |
| Creative Commons |
This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited. |
| Copyright |
Copyright © The Author(s), 2024. Published by Science Publishing Group |
Wastewater Reclamation, Smelting Wastewater, Coagulation-flocculation-sedimentation, UF, RO
| [1] | C. S. Rao, G. Gunasekaran, Cobalt-Lead-Manganese oxides combined cathode catalyst for air electrode in Zinc – air battery, Electrochimica Acta. 176 (2015) 649–656. |
| [2] | C. Spanos, D. E. Turney, V. Fthenakis, Life-cycle analysis of flow-assisted nickel zinc- manganese dioxide-, and valve-regulated lead-acid batteries designed for demand-charge reduction, Renewable and Sustainable Energy Reviews. 43 (2015) 478–494. |
| [3] | H. Y. Sohn, M. O. Martinez, Chapter 2.3 - Lead and Zinc Production, Treatise on Process Metallurgy. 3 (2014), 671-700. |
| [4] | W. Z. Yang, Y. Xie, S. F Fu, Y. Ren, J. Zhou, X. Y. Wang, J. K. Zhang, D. G. Yin, S. Zhao, The Tianshuihai lead–zinc deposit, Xinjiang province, NW China: A successful case of multi-scale geochemical mapping. Journal of Geochemical Exploration. 139 (2014) 136–143. |
| [5] | P. Z. Li, C. Y Lin, H. G. Cheng, X. L. Duan, K. Lei, Contamination and health risks of soil heavy metals around a lead/zinc smelter in southwestern China. Ecotoxicology and Environmental Safety. 113 (2015) 391–399. |
| [6] | W. B. Yan, Q. S. Mahmood, D. L. Peng, W. J. Fu, T. Chen, Y. Wang, S. Li, J. R. Chen, D. Liu, The spatial distribution pattern of heavy metals and risk assessment of moso bamboo forest soil around lead–zinc mine in Southeastern China. Soil & Tillage Research. 153 (2015) 120–130. |
| [7] | J. X. Zhou, Z. L. Huang, M. F. Zhou, X. K. Zhu, P. Muchez, Zinc, sulfur and lead isotopic variations in carbonate-hosted Pb–Zn sulfide deposits, southwest China. Ore Geology Reviews. 58 (2014) 41–54. |
| [8] | Ahmed Mandour, Mahmoud Kh. El-Sayed, Ayman A. El-Gamal, Ahmed M. Khadr, Ahmed Elshazly. Temporal distribution of trace metals pollution load index in the Nile Delta coastal surface sediments.Marine Pollution Bulletin. 167 (2021) 112290 |
| [9] | X. W. Zhang, L. S. Yang, Y. H. Li, H. R. Li, W. Y. Wang, Q. S. Ge, Estimation of lead and zinc emissions from mineral exploitation based on characteristics of lead/zinc deposits in China. Transaction of Nonferrous Metals Society of China. 21 (2011) 2513–2519. |
| [10] | A. Afkhami, M. S. Tehrani, H. Bagheri, Simultaneous removal of heavy metal ions in wastewater samples using nano-alumina modified with 2,4-dinitrophenylhydrazine, Journal of Hazardous Materials. 181 (2010) 836–844. |
| [11] | A. Coynel, J. Schäfer, A. Dabrin, N. Girardot, G. Blanc, Groundwater contributions to metal transport in a small river affected by mining and smelting waste, Water Research. 41 (2007) 3420–3428. |
| [12] | B. Pandey, M. Agrawal, S. Singh, Assessment of air pollution around coal mining area: Emphasizing on spatial distributions, seasonal variations and heavy metals, using cluster and principal component analysis, Atmospheric Pollution Research. 5 (2014) 79–86. |
| [13] | Smart C. Obor, Anthony Chukwu, Theophilus C. Davies, Heavy metals and health risk assessment of arable soils and food crops around Pbe Zn mining localities in Enyigba, southeastern Nigeria, Journal of African Earth Sciences. 116 (2016) 182–189. |
| [14] | H. Y. Zhan, Y. F. Jiang, J. M. Yuan, X. F. Hu, O. D. Nartey, B. L. Wang, Trace metal pollution in soil and wild plants from lead–zinc smelting are as in Huixian County, Northwest China, Journal of Geochemical Exploration. 147 (2014) 182–188. |
| [15] | M. S. Islam, M. K. Ahmed, M. Raknuzzaman, M. H. A. Mamun, G. K. Kundu, Heavy metals in the industrial sludge and their ecological risk: A case study for a developing country, Journal of Geochemical Exploration. 172 (2017) 41–49. |
| [16] | A. M. Shafaroudi, M. H. Karimpour, Mineralogic, Fluid inclusion, and sulfur isotope evidence for the genesis of Sechangi lead–zinc (–copper) deposit, Eastern Iran, Journal of African Earth Sciences. 107 (2015) 1–14. |
| [17] | W. Gottesmann, A. Kampe, Zn/Cd ratios in calcsilicate-hosted sphalerite ores at Tumurtijn-ovoo, Mongolia, Chemie der Erde Geochemistry. 67 (2007) 323–328. |
| [18] | L. C. Deng, Y. F. Zhang, F. F. Chen, S. T. Cao, S. W. You, Y. Liu, Y. Zhang, Reactive Crystallization of Calcium Sulfate Dihydrate from Acidic Wastewater and Lime, Chinese Journal of Chemical Engineering. 21 (11) (2013) 1303–1312. |
| [19] | L. Guo, Y. G. Du, Q. S. Yi, D. S. Li, L. W. Cao, D. Y. Du, Efficient removal of arsenic from ‘‘dirty acid’’ wastewater by using a novel immersed multi-start distributor for sulphide feeding, Separation and Purification Technology. 142 (2015) 209–214. |
| [20] | F. Zhang, Z. S. Zhao, R. Q. Tan, W. Xu, G. B. Jiang, W. J. Song, Efficient and selective immobilization of Pb2+ in highly acidic wastewater using strontium hydroxyapatite nanorods, Chemical Engineering Journal. 203 (2012) 110–114. |
| [21] | M. A. Shannag, Z. A. Qodah, K. B. Melhem, M. R. Qtaishat, M. Alkasrawi, Heavy metal ions removal from metal plating wastewater using electrocoagulation: Kinetic study and process performance, Chemical Engineering Journa. 1260 (2015) 749–756. |
| [22] | G. Sun, Arsenic contamination and arsenicosis in China, Toxicology and Applied Pharmacology. 198 (2004) 268–271. |
| [23] | S. Babel, T. A. Kurniawan, Low-cost adsorbents for heavy metals uptake from contaminated water: a review. Journal of Hazardous Materials. B97, (2003) 219–243. |
| [24] | B. J. Watten, P. L. Sibrell, M. F. Schwartz, Acid neutralization within limestone sand reactors receiving coal mine drainage, Environmental Pollution. 137 (2005) 295–304. |
| [25] | M. A. Batakat, New trends in removing heavy metals from industrial wastewater, Arabian Journal of Chemistry. 4 (2011) 361–377. |
| [26] | L. P. Wang, J. Ponou, S. J. Matsuo, K. Okaya, G. Dodbiba, T. Nazuka, T. Fujita, Integrating sulfidization with neutralization treatment for selective recovery of copper and zinc over iron from acid mine drainage, Minerals Engineering. 45 (2013) 100–107. |
| [27] | N. Georgios. Anastassakis, Physicochemical factors affecting flocculation of pre-reduced nickeliferous laterite suspension, Separation and Purification Technology. 45 (2005) 16–24. |
| [28] | Y. Xiao, X. D. Liu, D. X. Wang, Y. K. Lin, Y. P. Han, X. L. Wang, Feasibility of using an innovative PVDF MF membrane prior to RO for reuse of a secondary municipal effluent, Desalination. 311 (2013) 16–23. |
| [29] | S. J. You, D. H. Tseng, J. Y. Deng, Using combined membrane processes for textile dyeing wastewater reclamation, Desalination. 234 (2008) 426–432. |
| [30] | A. F. Razi, A. Pendashteh, Z. Z. Abidin, L. C. Abdullah, D. R. A. Biak, S. S. Madaeni, Application of membrane-coupled sequencing batch reactor for oilfield produced water recycle and beneficial re-use, Bioresource Technology. 101 (2010) 6942–6949. |
| [31] | I. Petrinic, J. Korenak, D. Povodnik, C. H. Nielsen, A feasibility study of ultrafiltration/reverse osmosis (UF/RO)-based wastewater treatment and reuse in the metal finishing industry, Journal of Cleaner Production. 101 (2015) 292-300. |
| [32] | X. F. Sun, C. W. Wang, Y. B. Li, W. G. Wang, J. Wei, Treatment of phenolic wastewater by combined UF and NF/RO processes, Desalination. 355 (2015) 68–74 |
| [33] | A. Y. Zahrim, N. Hilal, Treatment of highly concentrated dye solution by coagulation/flocculation–sand filtration and nanofiltration, Water Resources and Industry. 3 (2014) 23–34. |
| [34] | K. E. Lee, N. Morad, T. T. Teng, B. T. Poh, Development, characterization and the application of hybrid materials in coagulation/flocculation of wastewater: A review, Chemical Engineering Journal. 203 (2012) 370–386. |
| [35] | C. Sun, Q. Yue, B. Y. Gao, B. C. Cao, R. M. Mu, Z. B. Zhang, Synthesis and floc properties of polymeric ferric aluminium chloride-polydimethyl diallylammonium chloride coagulant in coagulating humid acid-kaolin synthetic water, Chemical Engineering Journal. 185–186 (2012) 29–34. |
| [36] | A. Capra, B. Scicolone, Recycling of poor quality urban wastewater by drip irrigation system. Journal of Cleaner Production. 15 (2007) 1529–1534. |
| [37] | A. Zouboulis, G. Traskas, P. Samaras, Comparison of single and dual media filtration in a full-scale drinking water treatment plant, Desalination. 213 (2007) 334–342. |
| [38] | M. Elbana, F. R. Cartagena, J. P. Bargués, Effectiveness of sand media filters for removing turbidity and recovering dissolved oxygen from a reclaimed effluent used for micro-irrigation, Agricultural Water Management. 111 (2012) 27–33. |
| [39] | H. Elfaki, A. Hawari, C. Mulligan, Enhancement of multi-media filter performance using talc as a new, filter aid material: Mechanistic study, Journal of Industrial and Engineering Chemistry. 24 (2015) 71–78. |
| [40] | S. Y. Jeong, R. Vollprecht, K. Cho, T. O. Leiknes, S. Vigneswaran, H. Bae, S. Lee, Advanced organic and biological analysis of dual media filtration used as a pretreatment in a full-scale seawater desalination plant, Desalination. 385, (2016) 82–92. |
| [41] | M. P. Varbanets, C. Zurbrügg, C. Swartz, W. Pronk, Decentralized systems for potable water and the potential of membrane technology. Water Research. 43, (2009) 245–265. |
| [42] | J. J. Qin, M. N. Wai, M. H. Oo, F. S. Wong, A feasibility study on the treatment and recycling of a wastewater from metal plating. Journal of Membrane Science. 208, (2002) 213–221. |
| [43] | W. Zuo, G. L. Zhang, Q. Meng, H. Z. Zhang, Characteristics and application of multiple membrane process in plating wastewater reutilization. Desalination. 222, (2008) 187–196. |
| [44] | F. Knops, S. V. Hoof, H. Futselaar, L. Broens, Economic evaluation of a new ultrafiltration membrane for pretreatment of seawater reverse osmosis, Desalination. 203 (2007) 300–306. |
| [45] | A. Qdaisa, H. Moussab, Removal of heavy metals from wastewater by membrane processes: a comparative study. Desalination. 164, (2004) 105–110. |
| [46] | Reverse osmosis and nanofiltration membrane technology manual of Dow FILMTEC (Chinese version), DOW Chemical. 2016, 185-191. |
| [47] | Y. Xiao, T. Chen, Y. J. Hu, D. H. Wang, Y. P. Han, Y. K. Lin, X. L. Wang, Advanced treatment of semiconductor wastewater by combined MBR–RO technology, Desalination. 336 (2014) 168–178. |
APA Style
Jiangtao Fu. (2021). Lead and Zinc Smelting Wastewater Treatment and Reclamation by Coagulation-Flocculation-Sedimentation, Ultrafiltration and Reverse Osmosis Technique. Journal of Energy, Environmental & Chemical Engineering, 6(4), 94-105. https://doi.org/10.11648/j.jeece.20210604.11
ACS Style
Jiangtao Fu. Lead and Zinc Smelting Wastewater Treatment and Reclamation by Coagulation-Flocculation-Sedimentation, Ultrafiltration and Reverse Osmosis Technique. J. Energy Environ. Chem. Eng. 2021, 6(4), 94-105. doi: 10.11648/j.jeece.20210604.11
AMA Style
Jiangtao Fu. Lead and Zinc Smelting Wastewater Treatment and Reclamation by Coagulation-Flocculation-Sedimentation, Ultrafiltration and Reverse Osmosis Technique. J Energy Environ Chem Eng. 2021;6(4):94-105. doi: 10.11648/j.jeece.20210604.11
Share This Article
Twitter
Linked In
Facebook
Copy
Download@article{10.11648/j.jeece.20210604.11,
author = {Jiangtao Fu},
title = {Lead and Zinc Smelting Wastewater Treatment and Reclamation by Coagulation-Flocculation-Sedimentation, Ultrafiltration and Reverse Osmosis Technique},
journal = {Journal of Energy, Environmental & Chemical Engineering},
volume = {6},
number = {4},
pages = {94-105},
doi = {10.11648/j.jeece.20210604.11},
url = {https://doi.org/10.11648/j.jeece.20210604.11},
eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.jeece.20210604.11},
abstract = {The typical smelting wastewater is with characteristics of high concentration of TDS, conductivity, heavy metal ions, and low concentration of COD. The ultrafiltration (UF) and reverse osmosis (RO) is an attractive technology to reclaim and reuse this kind of wastewater. In this work, Coagulation-flocculation-sedimentation (CFS) and multi-media filter (MMF) was used as the pretreatment processes. UF, RO and concentration RO (CRO) processes was applied as the advanced treatment processes to reclaim the smelting wastewater. To enlarge the recovery of RO and CRO units, the influences of increasing the feed temperature by waste heat from the smelting plant and the feed pressure by change the operating frequency of the high pressure pumps were investigated. The optimize operation parameters of RO and CRO units were obtained. To understand the operation CIP cycle time of UF, RO and CRO membrane units in a long term operation, the trans-membrane pressure (TMP) and permeate flux difference were investigate. Good system operation stability, permeate flux recovery after CIP and qualified treated water were obtained in the recommend operation parameters. The results of this work can benefit to the designing of reclaiming the smelting wastewater by UF-RO-CRO approach within the Lead and Zinc smelting industrial application.},
year = {2021}
}
TY - JOUR T1 - Lead and Zinc Smelting Wastewater Treatment and Reclamation by Coagulation-Flocculation-Sedimentation, Ultrafiltration and Reverse Osmosis Technique AU - Jiangtao Fu Y1 - 2021/09/30 PY - 2021 N1 - https://doi.org/10.11648/j.jeece.20210604.11 DO - 10.11648/j.jeece.20210604.11 T2 - Journal of Energy, Environmental & Chemical Engineering JF - Journal of Energy, Environmental & Chemical Engineering JO - Journal of Energy, Environmental & Chemical Engineering SP - 94 EP - 105 PB - Science Publishing Group SN - 2637-434X UR - https://doi.org/10.11648/j.jeece.20210604.11 AB - The typical smelting wastewater is with characteristics of high concentration of TDS, conductivity, heavy metal ions, and low concentration of COD. The ultrafiltration (UF) and reverse osmosis (RO) is an attractive technology to reclaim and reuse this kind of wastewater. In this work, Coagulation-flocculation-sedimentation (CFS) and multi-media filter (MMF) was used as the pretreatment processes. UF, RO and concentration RO (CRO) processes was applied as the advanced treatment processes to reclaim the smelting wastewater. To enlarge the recovery of RO and CRO units, the influences of increasing the feed temperature by waste heat from the smelting plant and the feed pressure by change the operating frequency of the high pressure pumps were investigated. The optimize operation parameters of RO and CRO units were obtained. To understand the operation CIP cycle time of UF, RO and CRO membrane units in a long term operation, the trans-membrane pressure (TMP) and permeate flux difference were investigate. Good system operation stability, permeate flux recovery after CIP and qualified treated water were obtained in the recommend operation parameters. The results of this work can benefit to the designing of reclaiming the smelting wastewater by UF-RO-CRO approach within the Lead and Zinc smelting industrial application. VL - 6 IS - 4 ER -
Information
Email: